How-To Blogs & Videos
Jenny Air Compressor General Setup, Maintenance, and Troubleshooting
This manual contains operation and service instructions for the Jenny Air Compressors.You will find this booklet a valuable guide to the proper and safe operation and maintenance of your new Jenny. It is intended to be used by anyone using or maintaining the equipment. Follow the instructions carefully and you will assure yourself of the utmost in compressed air efficiency and economy.Click here to open the 53 page Jenny Air Compressor manual
…
Apr 16, 2023
How To Operate and Maintain Rolair K Series Compressors
This manual contains operation and service instructions on how to maintain and operate your Rolair K Series compressor.You will find this manual a valuable guide to the proper and safe operation and maintenance of your K Series. It is intended to be used by anyone using or maintaining the equipment. Follow the instructions carefully and you will assure yourself of the utmost in compressed air efficiency and economy. Click Here to open the 34 page K Series compressor manual.
…
Aug 25, 2021
How-To Break In A New Air Compressor
This applies to a new Air Compressor, or a new Pump if you're replacing your old
Pump. Break-in periods should be anywhere from 30 to 60 minutes depending on the
type of Pump. To break in the unit, run it in cycle for the allotted time below. Turn the Drain
Cock at the bottom of the air receiver open so that air can escape while it's
running (not all the way, though). The unit will then pump up to max pressure,
shut off and turn on again in cycle. Smaller, Single-Stage Pumps
…
Aug 19, 2021
How-To Adjust An Unloader Valve
Unloader Valve Adjustment. Screw Unloader valve in to an approximate point where needle of the valve contacts the pump unloader pin. Attempt to blow air through the Unloader valve while turning the valve one round at a time. When you are able to blow air through the valve. Turn it in one more round and lock it down with the lock nut.The pump unloader pin should retract when the pump starts up.It is normal for an air flutter to vent from the unloader valve while running. This is the action o
…
Aug 16, 2021